全国咨询热线

400-879-1999

点击拨打服务热线:400-879-1999
你所在位置: 首页 >> 新闻中心 > 常见问题 >

常见问题

自上料搅拌车要检查什么事项呢?

作者:http://www.zkzsljbc.com 时间:2022-07-01

要检查配料斗里是否有积水,如有则清理干净;配料控制仪要特别小心,因为这是电子仪器一旦经过暴晒或雨淋或雷击就会受到损坏,将严重影响配料的准确性,从而影响工程的进度,所以配料控制仪放置位置应架设防晒、防雨、防尘、防雷等设施。
Check whether there is ponding in the batching hopper, and if so, clean it up; The batching controller should be particularly careful, because once the electronic instrument is exposed to the sun, rain or lightning, it will be damaged, which will seriously affect the accuracy of batching, thus affecting the progress of the project. Therefore, the placement position of the batching controller should be set up with sunscreen, rainproof, dustproof, lightning protection and other facilities.
同时对水泵、水箱、水管的积水进行排除,以免在严寒季节冻坏。水泥仓作为混凝土储备空间,也是搅拌机的主要设备之一,它的大部分材料都是钢板,因为经常暴露在空气中,肯定是容易腐蚀,所以一定要检查水泥仓的防腐工作,特别是检查水泥仓表面的防腐工作,看油漆涂刷是否完好,厚度、光滑度是否合格。
At the same time, the accumulated water in the water pump, water tank and water pipe shall be removed to avoid freezing damage in the severe cold season. As a concrete storage space, the cement silo is also one of the main equipment of the mixer. Most of its materials are steel plates. Because it is often exposed to the air, it must be easy to corrode. Therefore, we must check the anti-corrosion work of the cement silo, especially the anti-corrosion work of the surface of the cement silo, to see whether the paint is intact, and whether the thickness and smoothness are qualified.
自上料搅拌车
自上料搅拌车司机必须熟悉所操作机械的性能和操作方法,工作时应按规定穿戴好劳动防护用品。
The driver of self loading mixer truck must be familiar with the performance and operation method of the machinery operated, and wear labor protection articles as required during work.
工作前应检查传动离合器和制动器是否灵活可靠,爬斗钢丝绳有无断丝,搅拌机的大齿轮、皮带轮等传动部分防护罩是否完好,电动机接地是否良好,确认无误后方可工作。司机在机械运转中不准离开工作岗位,搅拌机运转时禁止用铁镐、铁锹或其他任何物件伸入拌合筒内。
Before work, check whether the transmission clutch and brake are flexible and reliable, whether the steel wire rope of the climbing bucket is broken, whether the protective covers of the driving parts such as the big gear and pulley of the mixer are intact, and whether the motor is well grounded. Work can be carried out only after confirmation. The driver is not allowed to leave the work position during the mechanical operation, and it is not allowed to stretch into the mixing drum with a pick, shovel or any other object during the operation of the mixer.
进料斗升起时,禁止任何人在斗下通过或停留。如必须在斗下检修,应停车切断电源,并将斗用保险链扣信或垫上枕木后方准进行。
No one is allowed to pass or stay under the hopper when the hopper is raised. If it is necessary to overhaul under the bucket, stop and cut off the power supply, and fasten the bucket with a safety chain or put a sleeper on it before proceeding.
严禁在喂料作业时,操作人员将头伸入料斗与机架间察看进料情况。如器需进入拌合筒内进行清洗工作时,应断开电源,取下熔断,并在开关箱上加锁,或由专人看管。
It is strictly forbidden for the operator to put his head between the hopper and the frame to observe the feeding condition during feeding operation. If the mixer needs to enter the mixing drum for cleaning, it should be disconnected from the power supply, removed from the fuse, and locked on the switch box, or watched by a specially assigned person.
以上便是问题的相关解答内容了,如果您想获取更多相关信息,就来关注我们网站http://www.zkzsljbc.com吧!
The above is the relevant answer to the question. If you want to get more relevant information, please follow our website http://www.zkzsljbc.com Come on!
新闻中心
联系我们
  • 公司:莱州聚峰机械有限公司
  • 热线:400-879-1999
  • 地址:山东省莱州市206国道与308省道交叉口东南50米

截屏,微信识别二维码