全国咨询热线

400-879-1999

点击拨打服务热线:400-879-1999
你所在位置: 首页 >> 新闻中心 > 常见问题 >

常见问题

自动上料搅拌车安全技术交底内容

作者:http://www.zkzsljbc.com 时间:2022-06-20

1、自动上料搅拌车应按施一组织设计方案确定的位置安装在平整、坚固的地方(如果确定位置的土壤松软)安装时应先夯实后安装),用支架稳定机体,安装的机械应按规定接地,其接地深度不应小于2m。电阻不超过40。
1. The automatic loading mixer shall be installed in a flat and solid place (if the soil at the determined position is soft) according to the position determined in the construction organization design scheme. The installation shall be tamped before installation). The machine body shall be stabilized with a support. The installed machinery shall be grounded according to the regulations, and the grounding depth shall not be less than 2m. The resistance shall not exceed 40.
2、机器必须由专人操作,其他人员不得随意打开或触摸。任何非机械操作人员擅自启动机器,都会造成事故和损坏。经济损失按细则处罚,并分别追究其责任。
2. The machine must be operated by a specially assigned person, and other personnel shall not open or touch it at will. Any non mechanical operator who starts the machine without authorization will cause accidents and damage. Economic losses shall be punished according to the detailed rules, and their responsibilities shall be investigated respectively.
3、每天上班前,一定要检查离合器、制动器、钢丝绳等装置是否完好有效,卷筒内是否有杂物。确认无误后即可进行操作。
3. Before going to work every day, be sure to check whether the clutch, brake, steel wire rope and other devices are in good condition and effective, and whether there are sundries in the drum. Operation can be carried out after confirmation.
4、进料斗升起后,严禁任何人通过或停留在料斗下方,以防刹车失灵造成事故。维修时,请先停止机器,并用安全链将料斗挂起,然后再进行操作。
4. After the feed hopper is lifted, no one is allowed to pass or stay under the hopper to prevent accidents caused by brake failure. During maintenance, please stop the machine and hang the hopper with safety chain before operation.
5、搅拌机应先启动,再上料,正常运转后再上料,防止机械功率过大烧坏零件。
5. The mixer shall be started first, then loaded, and then loaded after normal operation to prevent the parts from being burned by excessive mechanical power.
6、严禁在自动上料搅拌车操作过程中将头部、身体和工具放入搅拌机内。工作完成后,应清洗机器并上油,以保持机器的清洁和润滑。把料斗竖起来,用安全链挂起来。
6. It is forbidden to put the head, body and tools into the mixer during the operation of the automatic feeding mixer. After the work is completed, the machine shall be cleaned and oiled to keep the machine clean and lubricated. Erect the hopper and hang it with a safety chain.
自动上料搅拌车
7、现场检修时,应切断电源,固定好料斗后,方可进行。有人在修,禁止关闭开关。
7. During on-site maintenance, the power supply shall be cut off and the hopper shall be fixed before maintenance. It is forbidden to turn off the switch when someone is repairing.
8、严禁带病机械和超负荷运转。必须对违反者进行调查。
8. It is strictly forbidden to operate machinery with faults and overload. Violators must be investigated.
9、严禁酒后操作机械和擅自离岗。违反者将受到严厉处罚。
9. It is strictly prohibited to operate machinery after drinking and leave the post without authorization. Violators will be severely punished.
10、本机配有闸刀、箱、锁。操作人员必须爱护它们,包括不能丢失的塑料盖和盖子,并且在下班时应关闭大门锁。
10. This machine is equipped with knife switch, box and lock. Operators must take good care of them, including plastic covers and covers that cannot be lost, and close the door lock when off duty.
11、机器运行过程中,如突然断电,应随时关闭机器,以防人走后突然来电,机器自行运转,造成故障。
11. In case of sudden power failure during the operation of the machine, the machine shall be shut down at any time to prevent the machine from running on its own and causing faults.
12、交班时,必须办理交接手续,每天记录自动上料搅拌车的操作和交接情况。
12. When the shift is handed over, the handover procedures must be handled, and the operation and handover of the automatic feeding mixer truck must be recorded every day.
以上就是今天为大家分享的关于问题的相关内容,希望对大家能有所帮助,想要了解更多内容可以电话联系我们或者关注我们的网站http://www.zkzsljbc.com。
The above is the relevant content about the problem shared for you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website http://www.zkzsljbc.com 。
新闻中心
联系我们
  • 公司:莱州聚峰机械有限公司
  • 热线:400-879-1999
  • 地址:山东省莱州市206国道与308省道交叉口东南50米

截屏,微信识别二维码