全国咨询热线

400-879-1999

点击拨打服务热线:400-879-1999
你所在位置: 首页 >> 新闻中心 > 常见问题 >

常见问题

使用搅拌机过程中会有的操作

作者:http://www.zkzsljbc.com 时间:2022-05-16

使用全自动搅拌车时,需要将机器放置在相对平坦的工作台上,前后轴用方木块垫好,使轮胎处于架空状态。这样做的目的是避免搅拌机在启动时移动现象。接下来了解更多关于设备的内容。
When using the full-automatic mixer, the machine needs to be placed on a relatively flat workbench, and the front and rear axles are padded with square wood blocks to make the tires in an overhead state. The purpose of this is to avoid the movement of the mixer when starting. Next, learn more about the device.
一般情况下,搅拌机需要进行二次漏电保护。通电后需要仔细进行空车试车,确认没有问题后即可使用。搅拌机运转时,应观察搅拌筒的运转情况。速度是否正常,一般来说,空车运行的速度比装载后的运行速度快2到3圈左右。如果转数相差很大,则需要调整传动轮与驱动轮的传动比。
Generally, the mixer needs secondary leakage protection. After power on, it is necessary to carefully carry out empty vehicle test run, and it can be used after confirming that there is no problem. When the mixer is running, observe the operation of the mixing drum. Whether the speed is normal. Generally speaking, the speed of empty vehicle is about 2 to 3 laps faster than that after loading. If the number of revolutions varies greatly, the transmission ratio between the driving wheel and the driving wheel needs to be adjusted.
全自动搅拌车厂家
然后确认搅拌筒的转动方向是否与箭头所指方向一致。如果不一样,则需要立即更改电机的接线,使其方向一致。在使用中检查离合器和制动器的灵敏度,确认钢丝绳是否损坏,轨道的滑轮是否完好,搅拌机周围是否有障碍物,各部件润滑是否充分,当操作完成或不需要时,必须关闭闸门电源,并锁好开关盒。
Then confirm whether the rotation direction of the mixing drum is consistent with the direction indicated by the arrow. If not, the wiring of the motor needs to be changed immediately to make its direction consistent. During use, check the sensitivity of the clutch and brake to confirm whether the steel wire rope is damaged, whether the pulley of the track is intact, whether there are obstacles around the mixer and whether the lubrication of all parts is sufficient. When the operation is completed or not, the power supply of the gate must be turned off and the switch box must be locked.
搅拌机分散盘底部呈层流状态,不同流速的浆料层相互扩散,起到分散作用。高速分散机具有液压升降、360度旋转、无级调速等多种功能。可同时配装2-4个容器,液压升降行程1000mm,360度旋转功能更能满足一机多用功能,可在一次油缸之间换油。很短的时间。提高了工作效率,同时降低了劳动强度。
The bottom of the mixer dispersion plate is in a laminar flow state, and the slurry layers with different flow rates diffuse each other to play a role in dispersion. The high-speed disperser has many functions, such as hydraulic lifting, 360 degree rotation, stepless speed regulation and so on. The hydraulic oil cylinder can be installed between 360-1000mm at the same time, and can be installed with multiple functions at one time. A short time. It improves the work efficiency and reduces the labor intensity.
全自动搅拌车厂家提醒,全自动搅拌车主要对不同粘度的液体原料进行粉碎、分散、乳化和混合。新型高效混合设备通过分散盘上下齿的高速运转,进行高速强剪切、冲击、粉碎、分散,达到快速混合、溶解、分散、分散等功能精制。
The manufacturer of full-automatic mixer reminds that the full-automatic mixer is mainly used to crush, disperse, emulsify and mix liquid raw materials with different viscosities. Through the high-speed operation of the upper and lower teeth of the dispersion disk, the new high-efficiency mixing equipment can carry out high-speed and strong shear, impact, crushing and dispersion, so as to achieve the functions of rapid mixing, dissolution, dispersion and dispersion.
使用搅拌机需要注意的主要内容有这些,您需要在使用中按照说明正确操作。只有这样,才能充分发挥其性能。更多关于搅拌机的信息将继续为您整理,可以关注网站www.zkzsljbc.com查看。
These are the main contents that should be paid attention to when using the mixer. You need to operate correctly according to the instructions during use. Only in this way can its performance be brought into full play. More information about the mixer will continue to be sorted out for you. You can follow the website www.zkzsljbc.com Com.
新闻中心
联系我们
  • 公司:莱州聚峰机械有限公司
  • 热线:400-879-1999
  • 地址:山东省莱州市206国道与308省道交叉口东南50米

截屏,微信识别二维码