全国咨询热线

400-879-1999

点击拨打服务热线:400-879-1999
你所在位置: 首页 >> 新闻中心 > 公司新闻

公司新闻

作为自上料搅拌车司机要注意几点

作者:http://www.zkzsljbc.com 时间:2022-11-04

搅拌车所运输的混凝土对整个建筑物的质量来说是非常重要的,所以搅拌车司机的责任是非常重大的,在工作中有许多的细节需要掌握,否则不管哪个方面出问题都是非常严重的。作为搅拌车的司机要注意一下几点:
The concrete transported by the mixer is very important to the quality of the whole building, so the responsibility of the mixer driver is very important. There are many details to master in the work, otherwise, no matter what aspect of the problem is very serious. As a mixer driver, pay attention to the following points:
1.搅拌车所运输的混凝土要保证其质量及塌落度符合混凝土行业的标准及要求。
1. The quality and slump of the concrete transported by the mixer truck shall meet the standards and requirements of the concrete industry.
2.自上料搅拌车在道路上行驶,其上装的加长料槽要放置在卸料溜槽的支架上并用挂钩固定好,不允许挂在主排料槽上工作,主卸料槽要旋转到固定的位置,拉下定位手柄,用锁紧手柄将弹簧变幅组织锁紧,避免由于不固定而晃动,造成伤人及其它事故。
2. When the self loading mixer is running on the road, the extended chute installed on it shall be placed on the support of the discharge chute and fixed with hooks. It is not allowed to hang on the main discharge chute for work. The main discharge chute shall be rotated to the fixed position, the positioning handle shall be pulled down, and the spring luffing organization shall be locked with the locking handle to avoid personal injury and other accidents caused by shaking due to non fixation.
3.搅拌车上装设备连续工作时间不能超过8个小时。
3. The continuous working time of the equipment mounted on the mixer truck shall not exceed 8 hours.
4.自上料搅拌车在混凝土运输过程中上装罐体不能停转,否则会造成混凝土凝结,而且停转后重新启动时会对液压系统和减速机造成冲击,导致液压泵和马达的损坏。
4. The self feeding mixer can not stop loading the tank during concrete transportation, otherwise it will cause concrete condensation, and the hydraulic system and reducer will be impacted when it is restarted after stopping, resulting in damage to the hydraulic pump and motor.
5.搅拌车在卸料的时候,如果发现混凝土水分蒸发过多,塌落度偏低,不能满足质量要求,可以适当的往罐内加水,然后以10-14转/分的速度旋转30分钟后再卸料,让混凝土充分搅拌。
5. When the mixer truck is discharging, if it is found that the concrete has too much water evaporation and low slump, which cannot meet the quality requirements, it can add water to the tank properly, and then rotate at the speed of 10-14 rpm for 30 minutes before discharging, so that the concrete can be fully mixed.
自上料搅拌车
6.搅拌车在空载中上装罐体也不可以停转,否则在行车过程中车辆的晃动很容易造成滚道和托轮部分磕碰的,这样托轮和滚道就会过早的损坏。
6. The mixer truck can not be stopped when loading the tank in the empty load, otherwise the rolling way and supporting wheel will be collided easily due to the shaking of the vehicle during driving, so that the supporting wheel and the rolling way will be damaged prematurely.
7.搅拌车驾驶员要记住,在工作过程中压力水箱的水要常常加满,备用,在水箱加水前要打开气阀将内部的空气放掉,在冲洗车辆后或者停用时要将水箱内的空气放掉。在冬天,工作结束后要将水箱内的水放掉,不得有剩水,否则容易结冰冻坏水箱。
7. The mixer driver should remember that the water in the pressure water tank should always be filled up for standby during the working process. Before the water tank is filled, the air valve should be opened to drain the air inside, and the air inside the water tank should be drained after washing the vehicle or when it is not used. In winter, the water in the water tank shall be drained after the work is completed, and there shall be no water left, otherwise the water tank may be frozen and damaged.
8.自上料搅拌车在满载混凝土时罐体正转,如果需要反转,就须等罐体停稳后再将手柄扳到反转位置。
8. When the self feeding mixer truck is fully loaded with concrete, the tank body rotates forward. If it needs to reverse, the handle must be pulled to the reverse position after the tank body stops stably.
搅拌车的行驶环境一般都比较差,所以为了自身以及设备完好,合格的搅拌车司机就要做到以上这几点。更多相关内容就来我们网站http://www.zkzsljbc.com咨询了解吧!
The driving environment of the mixer is generally poor, so qualified mixer drivers should do the above for their own safety and equipment integrity. More relevant content will come to our website http://www.zkzsljbc.com Ask and understand!
新闻中心
联系我们
  • 公司:莱州聚峰机械有限公司
  • 热线:400-879-1999
  • 地址:山东省莱州市206国道与308省道交叉口东南50米

截屏,微信识别二维码